2021 KTM 250 Adventure

COMBINATION INSTRUMENT

The indicator lamps offer additional information about the operating state of the motorcycle. When the ignition is switched on, all indicator lamps light up briefly except for the turn signal indicator lamp. As soon as a warning for operating safety has been detected, the general warning lamp also lights up.

Info
The malfunction indicator lamp always lights up as long as the engine is not running. If the engine is running and the malfunctioning indicator lamp lights up, stop (taking care not to endanger yourself or other road users in the process) and contact an authorized KTM workshop. The ABS warning lamp lights up until a speed of approx. 6 km/h (approx. 4 mph) or more has been reached.

Info
The time must be reset if the 12-V battery was disconnected from the vehicle or the fuse was removed. The brightness of the displays is controlled by an ambient light sensor in the combination instrument.

Degrees of risk and symbols

Danger
Identifies a danger that will immediately and invariably lead to fatal or serious permanent injury if the appropriate measures are not taken.

Warning
Identifies a danger that is likely to lead to fatal or serious injury if the appropriate measures are not taken.

Caution
Identifies a danger that may lead to minor injuries if the appropriate measures are not taken.

Note
Identifies a danger that will lead to considerable machine and material damage if the appropriate measures are not taken.

Note
Indicates a danger that will lead to environmental damage if the appropriate measures are not taken.

Tampering warning

Tampering with the noise control system is prohibited. Federal law prohibits the following acts or the causing thereof:

1. The removal or rendering inoperative by any person other than for purposes of servicing, repair, or replacement, of any device or element of design incorporated into any new vehicle for the purpose of noise control prior to its sale or delivery to the ultimate purchaser or while it is in use, or 2 the use of the vehicle after such device or element of design has been removed or rendered inoperative by any person.

Among those acts presumed to constitute tampering are the acts listed below:

1. Removal or puncturing of the main silencers, baffles, header pipes, or any other components which conduct exhaust gases.
2. Removal or puncturing of parts of the intake system.
3. Lack of proper maintenance.
4. Replacing moving parts of the vehicle, or parts of the exhaust system or intake system, with parts other than those specified by the manufacturer.

Safe operation
Danger
The danger of accidents A rider who is not fit to ride poses a danger to him or herself and others.

• Do not operate the vehicle if you are not fit to ride due to alcohol, drugs, or medication.
• Do not operate the vehicle if you are physically or mentally impaired.

Danger
The danger of poisoning Exhaust gases are toxic and inhaling them may result in unconsciousness and death.

• Always make sure there is sufficient ventilation when running the engine.
• Use effective exhaust extraction when starting or running the engine in an enclosed space.

Warning
The danger of burns Some vehicle components become very hot when the vehicle is operated.

• Do not touch any parts such as the exhaust system, radiator, engine, shock absorber, or brake system before the vehicle parts have cooled down.
• Let the vehicle parts cool down before you perform any work on the vehicle.

Only operate the vehicle when it is in perfect technical condition, in accordance with its intended use, and in a safe and environmentally compatible manner. An appropriate driver’s license is needed to ride the vehicle on public roads. Have malfunctions that impair safety are promptly eliminated by an authorized KTM workshop. Adhere to the information and warning labels on the vehicle.

Protective clothing
Warning
Risk of injury Missing or poor protective clothing presents an increased safety risk.

• Wear appropriate protective clothing such as helmets, boots, gloves as well as trousers, and a jacket with protectors on all rides.
• Always wear protective clothing that is in good condition and meets the legal regulations.

In the interest of your own safety, KTM recommends that you only operate the vehicle while wearing protective clothing.

Work rules
Unless specified otherwise, the ignition must be turned off during all work (models with the ignition lock, models with remote key) or the engine must be at a standstill (models without ignition lock or remote key). Special tools are necessary for certain tasks. The tools are not a component of the vehicle, but can be ordered using the number in parentheses. Example: bearing puller (15112017000) During assembly, use new parts to replace parts which cannot be reused (e.g. self-locking screws and nuts, expansion screws, seals, sealing rings, O-rings, pins, and lock washers). In the case of certain screws, a screw adhesive (e.g., Loctite®) is required. Observe the manufacturer’s instructions. If a screw adhesive (e.g., Precote®) has already been applied to a new part, do not apply any additional thread locker. After disassembly, clean the parts that are to be reused and check them for damage and wear. Change damaged or worn parts. After completing a repair or service work, check the operating safety of the vehicle.

Environment
If you use your motorcycle responsibly, you can ensure that problems and conflicts do not occur. To protect the future of the motorcycle sport, make sure that you use your motorcycle legally, display environmental consciousness, and respect the rights of others. When disposing of used oil, other operating and auxiliary fluids, and used components, comply with the laws and regulations of the respective country. Because motorcycles are not subject to the EU regulations governing the disposal of used vehicles, there are no legal regulations that pertain to the disposal of an end-of-life motorcycle. Your authorized KTM dealer will be glad to advise you.

Owner’s Manual
Read this owner’s manual carefully and completely before making your first trip. The Owner’s Manual contains useful information and many tips on how to operate, handle, and service your motorcycle. This is the only way to find out how best to customize the vehicle for your own use and how you can protect yourself from injury.

Tip
Store the Owner’s Manual on your terminal device, for example, so that you can read it whenever you need to.

If you would like to know more about the vehicle or have questions on the material you read, please contact an authorized KTM dealer.
The Owner’s Manual is an important component of the vehicle. If the vehicle is sold, the Owner’s Manual must be downloaded again by the new owner. The Owner’s Manual can be downloaded several times using the QR code or the link on the delivery certificate. The Owner’s Manual is also available for download from your authorized KTM dealer and on the KTM website. A printed copy can also be ordered from your authorized KTM dealer.
International KTM Website: http://www.ktm.com

Manufacturer warranty implied warranty
The work prescribed in the service schedule must only be carried out in an authorized KTM workshop and confirmed in the KTM Dealer.net, as otherwise, all warranty claims will be void. Damage or secondary damage caused by tampering with and/or conversions on the vehicle is not covered by the manufacturer’s warranty.

Fuel, auxiliary substances
Note
Environmental hazard Improper handling of fuel is a danger to the environment.

• Do not allow fuel to enter the groundwater, the soil, or the sewage system.
  Use fuels and auxiliary substances in accordance with the Owner’s Manual and specifications.

Spare parts, accessories
For your own safety, only use spare parts and accessory products that are approved and/or recommended by KTM and have them installed by an authorized KTM workshop. KTM accepts no liability for other products and any resulting damage or loss. Certain spare parts and accessory products are specified in parentheses in the descriptions. Your authorized KTM dealer will be glad to advise you. The current KTM PowerParts for your vehicle can be found on the KTM website.
International KTM Website: http://www.ktm.com

FAQ